GM, Chrysler recalling hundreds of thousands of vehicles
Jeeps, Durangos, Cadillacs and Impalas among models affected
General Motors and Chrysler are both recalling hundreds of thousands of vehicles with faulty parts that can cause injury. The impacted models include the Cadillac XTS, Chevrolet Impala sedans, the Jeep Grand Cherokees and Dodge Durangos.
General Motors is recalling 221,558 Cadillac XTS and Chevrolet Impala sedans because the brake pads can stay partially engaged even when they're not needed, increasing the risk of a fire.
- Chrysler recalls Jeep SUVs due to defective ignition switches
- GM admits more problems with mislabelling of ignition switch parts
The recall involves Cadillacs from the 2013-2015 model years and Impalas from the 2014 and 2015 model years. There are 205,309 vehicles affected in the U.S.; the rest of the vehicles are in Canada and elsewhere.
GM says the electronic parking brake arm that applies pressure to the back of the brake pads may not fully retract after use. If the brake pads stay partially engaged with the rotor, excessive brake heat may result in a fire.
GM says it knows of no accidents or injuries related to the defect.
GM will notify owners and repair the vehicles for free.
Fuel pump problem leads to stalling
Chrysler is recalling almost 189,000 Jeep Grand Cherokees and Dodge Durangos in the U.S. to fix a fuel pump problem that can cause the SUVs to stall.
But a safety advocate says the recall doesn't cover enough models, contending the same problem can happen in millions of other Chrysler, Jeep and Ram vehicles.
The recall, posted Saturday by the National Highway Traffic Safety Administration, covers some 2011 models with 3.6-liter V6 or 5.7-liter V8 engines. Chrysler says a relay can fail, increasing the risk of a crash, although the company said that as of Aug. 25, it wasn't aware of any crashes or injuries from the problem.
The company began looking into the problem in October 2013 and traced it to a spring that can become deformed because of heat.
The vehicles also might not start, and the fuel pump could keep working even when the engine is shut off.
The recall covers SUVs built from Jan. 25, 2010 through July 20, 2011, according to the NHTSA documents.
Dealers will replace the fuel pump relay for free starting Oct. 24.
‘Chrysler should recall them all’
The Center for Auto Safety, a non-profit advocacy group founded by Ralph Nader, says the recall is inadequate because more than 5 million other Chrysler vehicles have the same fuel pump power control module as the Grand Cherokee and Durango.
"Chrysler should recall them all," Clarence Ditlow, the centre's executive director, said Saturday.
Ditlow's group filed a petition last month asking NHTSA to investigate power system failures in Chrysler vehicles that could cause them to stall while being driven.
In the petition, the group contended that an electrical power control module used by Chrysler in millions of vehicles since 2007 can go haywire, causing them to stall in traffic and cut off devices powered by electricity.
The allegation covered Ram pickup trucks, Chrysler and Dodge minivans, the Jeep Grand Cherokee, Dodge Durango and Dodge Journey SUVs, the Jeep Wrangler, and other models.
The safety group says it has received over 70 complaints and that the government has received hundreds.
NHTSA has yet to make a decision on whether to investigate the matter. Chrysler said it is investigating consumer complaints and retrieving components from vehicles in the field for a closer analysis. The company says its vehicles meet all federal safety standards.
The centre's petition said that Chrysler's "Totally Integrated Power Module," which includes a computer, relays and fuses, distributes electrical power through the entire vehicle. In addition to stalling, the faulty modules have may have caused air bags not to inflate and fuel pumps to keep running, causing unintended acceleration and fires, the petition said.
Ditlow said the company started phasing them out in 2012, but they remain in the 2014 Jeep Wrangler and the Dodge and Chrysler minivans.
NHTSA also is looking into a New Jersey man's petition filed earlier this month alleging that Chrysler minivans can stall unexpectedly after refuelling.
Car owners and advocacy groups can petition the NHTSA asking for investigations that sometimes lead to recalls. The Center for Auto Safety has successfully petitioned NHTSA in the past, including one instance that led to the recent recall of 1.56 million older Jeep SUVs with fuel tanks mounted behind the rear axles.
The centre contended the tanks can leak fuel and cause fires in a crash, while Chrysler maintains the tanks perform as well as comparable models from other automakers.