Product Recall
Polaris snowmobiles recalled for steering hazard
April 11, 2006

Polaris Industries Inc., is recalling about 3,300 snowmobiles after it was discovered that a fastener torque securing the starter motor to the engine crankcase may not have been accurately applied during the manufacture of these snowmobiles or during the installation of an accessory starter.

An improperly torqued starter motor fastener bolt may become loose and fall out allowing the bolt to interfere with the lower steering drag link. This could allow the consumer to experience a loss of steering control.

Polaris has received 18 reports of incidents involving loss of steering ability, with one reported minor injury. Consumers should stop using the product immediately unless otherwise instructed.

Only certain 2005 and 2006 Polaris snowmobiles with electric starts and models with electric start kits are affected.

The recall includes Polaris Model Year 2006 700IQ Classic, 700 IQ Touring, Select Model Year 2005 900 Fusion, 900 RMK, 900 Switchback, Select Model Year 2006 700 IQ Fusion, RMK, and Select Model Year 2006 900 Fusion, RMK Switchback Snowmobiles with Accessory Electric Start Kits.

The model and serial number (VIN) identification decal is located on the right side of the tunnel underneath the seat.

The table below lists all models possibly affected by the recall:

Note: Not all Model Year 2005 and 2006 snowmobiles are affected.

Consumers with recalled snowmobiles are being sent direct notice from Polaris. Consumers should stop using these vehicles immediately and contact a local Polaris snowmobile dealer to schedule an appointment for a free repair.